Preparation and characterisation of kaempferol composite carrier solid dispersion: evaluation of its application in preventing soybean oil spoilage.

Kaempferol (KPF) can be used as a natural antioxidant and food additive in food processing. However, the poor solubility of KPF limited its bioavailability and application. In order to improve the solubility of KPF, kaempferol composite carrier solid dispersion (KPF-CC-SD) was prepared and the process was optimised. When the ratio of KPF: CA (citric acid): Soluplus reached 1:4:6, the dissolution rate was the highest, and the sample was stable over 12 weeks. The characterisation results indicated that KPF-CC-SD exists in an amorphous form. Peroxidation value and acid value of soybean oil showed that the preservation effect of KPF-CC-SD was better than that of KPF, and the inhibition effect of KPF-CC-SD on acid value was better than that of butylated hydroxytoluene. In conclusion, KPF-CC-SD can change the solubility, crystal form and spatial stability of KPF through the carrier, which has a great application prospect in the field of food preservation.

Comparative evaluation of physicochemical and antimicrobial properties of rubber seed oil from different regions of Bangladesh.

In Bangladesh, the annual production of rubber seeds is typically left untapped although the seeds contained a high percentage of oil but underutilized without any value-added utilization. This study aims to evaluate the geographical effect on physicochemical properties, fatty acid composition and the antimicrobial activity of oil extracted from rubber seeds. Seeds were collected from three different regions of Bangladesh and the oil was extracted by the soxhlet method using n-hexane as a solvent. Results demonstrated that the geographical regions have some significant effect on the properties of rubber seed oil (RSO). The physicochemical properties of RSO varied from region to region. For example, the percent of yield, higher heating value, and flash point varied from 50.0 to 50.8 %, 31.8-33.3 kJ/g, and 237-245 °C, respectively. The chemical parameters, such as acid value, iodine value, and hydroxyl value varied from 13.3 to 18.2 mg KOH/g, 132-137 g I2/100g, and 47.7-55.8 mg KOH/g, respectively. Chromatographic analysis showed that RSO mainly contains palmitic, linoleic, linolenic, and stearic acid. Regional variations were also seen in the composition of these fatty acids. Most notably, regardless of the rubber seeds collected from various locations, RSO exhibited inhibitory activity against only gram positive bacteria. The zone of inhibition range for different tested gram positive bacteria was 2.33-11.17 mm irrespective of different RSO samples.

A novel method for determination of peroxide value and acid value of extra-virgin olive oil based on fluorescence internal filtering effect correction.

Peroxide value (PV) and acid value (AV) are widely used indicators for evaluating oxidation degree of olive oils. Fluorescence spectroscopy has been extensively studied on the detection of oil oxidation, however, the detection accuracy is limited due to internal filtering effect (IFE). Due to the primary and secondary IFE, at least two wavelengths of absorption information are required. Least squares support vector regression (LSSVR) models for PV and AV were established based on two absorption coefficients (µa) at 375 nm and emission wavelength and one fluorescence intensity at corresponding wavelength. The regression results proved that the model based on 375 and 475 nm could reach the best performance, with the highest correlation coefficient for prediction (rp) of 0.889 and 0.960 for PV and AV respectively. Finally, the explicit formulations for PV and AV were determined by nonlinear least squares fitting, and the rp could reach above 0.94 for two indicators.

The bioprotective role of irradiated hibiscus against harmful effects of using repeatedly frying edible oil

Abstract Repeatedly frying process of dietary edible oil has a potential role in the generation of free radicals. Therefore, questions have always been raised as to whether, there is an efficient and economical method to reduce the harmful effects of repeated use of frying edible oil. Since hibiscus has been stated to have a wide variety of therapeutic effects, it was important to investigate its properties against harmful effects of free radicals. The current study aspires to find out whether irradiated powder of hibiscus has a protective role against adverse effects of repeated use of frying edible oil. Thirty-five adult male albino rats were equally assigned into five groups. First groupG1 was fed with normal diet as control group, meanwhile, groupG2 the diet mixed with fresh oil, G3 diet mixed with repeatedly frying oil only, G4 diet mixed with frying oil treated with hibiscus and G5 diet mixed with frying oil treated with irradiated hibiscus. Feeding duration was six weeks. Fatty acid analyses of oil as well as peroxide values were determined. Blood and liver samples were collected for biochemical analyses as well as histological study. Repeatedly heated cooked oil has significant increases in peroxide value, acid value, free fatty acid and both conjugated diene and triene compared with repeatedly frying oil treated with hibiscus. Also there are significant increases in cholesterol and triglyceride and impaired in liver functions in G3compared with others. In addition, relative to the hibiscus groups, there is a substantial reduction in oxygen consumption in G3. Both hibiscus as well as irradiated hibiscus attract attention in order to play a vital and economical role against harmful effects of frequent use of frying edible oil on some biological functions but, irradiated hibiscus was more effective.

Resumo O processo de fritura repetida de óleo comestível da dieta tem papel potencial na geração de radicais livres que podem ter efeitos prejudiciais em algumas funções biológicas. Portanto, sempre se questionou se existe uma maneira eficiente e econômica de prevenir ou pelo menos reduzir os efeitos nocivos do uso repetido de óleo comestível para fritar. Como o hibisco tem ampla variedade de efeitos terapêuticos, foi importante investigar suas propriedades como agente antioxidante contra os efeitos nocivos dos radicais livres. O presente estudo pretende descobrir se o pó irradiado de hibisco tem papel protetor contra os efeitos adversos do uso repetido de óleo comestível para fritar. Trinta e cinco ratos albinos machos adultos foram divididos igualmente em cinco grupos. O primeiro grupo G1 foi alimentado com dieta normal como grupo controle, enquanto o grupo G2 dieta misturada com óleo fresco, dieta G3 misturada com óleo de fritura repetida, dieta G4 misturada com óleo de fritura tratada com hibisco e dieta G5 misturada com óleo de fritura tratada com hibisco irradiado. A duração da alimentação foi de seis semanas. Foram determinadas as análises de ácidos graxos de óleo, bem como os valores de peróxidos. Amostras de sangue e fígado foram coletadas para análises bioquímicas e estudo histológico. O óleo cozido repetidamente aquecido tem aumentos significativos no valor de peróxido, valor de ácido, ácido graxo livre e dieno e trieno conjugados em comparação com óleo de fritura repetidamente tratado com hibisco. Também há aumentos significativos no colesterol e triglicérides e comprometimento das funções hepáticas no G3 em comparação com outros. Além disso, em relação aos grupos de hibiscos, há uma redução substancial no consumo de oxigênio no G3. Tanto o hibisco como o hibisco irradiado chamam atenção por desempenhar papel vital e econômico contra os efeitos nocivos do uso frequente de óleo comestível para fritar em algumas funções biológicas, mas o hibisco irradiado foi mais eficaz.

The bioprotective role of irradiated hibiscus against harmful effects of using repeatedly frying edible oil / O papel bioprotetor do hibisco irradiado contra os efeitos nocivos do uso de óleo comestível para fritar

Abstract Repeatedly frying process of dietary edible oil has a potential role in the generation of free radicals. Therefore, questions have always been raised as to whether, there is an efficient and economical method to reduce the harmful effects of repeated use of frying edible oil. Since hibiscus has been stated to have a wide variety of therapeutic effects, it was important to investigate its properties against harmful effects of free radicals. The current study aspires to find out whether irradiated powder of hibiscus has a protective role against adverse effects of repeated use of frying edible oil. Thirty-five adult male albino rats were equally assigned into five groups. First group"G1" was fed with normal diet as control group, meanwhile, group"G2" the diet mixed with fresh oil, "G3" diet mixed with repeatedly frying oil only, "G4" diet mixed with frying oil treated with hibiscus and "G5" diet mixed with frying oil treated with irradiated hibiscus. Feeding duration was six weeks. Fatty acid analyses of oil as well as peroxide values were determined. Blood and liver samples were collected for biochemical analyses as well as histological study. Repeatedly heated cooked oil has significant increases in peroxide value, acid value, free fatty acid and both conjugated diene and triene compared with repeatedly frying oil treated with hibiscus. Also there are significant increases in cholesterol and triglyceride and impaired in liver functions in "G3"compared with others. In addition, relative to the hibiscus groups, there is a substantial reduction in oxygen consumption in "G3". Both hibiscus as well as irradiated hibiscus attract attention in order to play a vital and economical role against harmful effects of frequent use of frying edible oil on some biological functions but, irradiated hibiscus was more effective.

Resumo O processo de fritura repetida de óleo comestível da dieta tem papel potencial na geração de radicais livres que podem ter efeitos prejudiciais em algumas funções biológicas. Portanto, sempre se questionou se existe uma maneira eficiente e econômica de prevenir ou pelo menos reduzir os efeitos nocivos do uso repetido de óleo comestível para fritar. Como o hibisco tem ampla variedade de efeitos terapêuticos, foi importante investigar suas propriedades como agente antioxidante contra os efeitos nocivos dos radicais livres. O presente estudo pretende descobrir se o pó irradiado de hibisco tem papel protetor contra os efeitos adversos do uso repetido de óleo comestível para fritar. Trinta e cinco ratos albinos machos adultos foram divididos igualmente em cinco grupos. O primeiro grupo "G1" foi alimentado com dieta normal como grupo controle, enquanto o grupo "G2" dieta misturada com óleo fresco, dieta "G3" misturada com óleo de fritura repetida, dieta "G4" misturada com óleo de fritura tratada com hibisco e dieta "G5" misturada com óleo de fritura tratada com hibisco irradiado. A duração da alimentação foi de seis semanas. Foram determinadas as análises de ácidos graxos de óleo, bem como os valores de peróxidos. Amostras de sangue e fígado foram coletadas para análises bioquímicas e estudo histológico. O óleo cozido repetidamente aquecido tem aumentos significativos no valor de peróxido, valor de ácido, ácido graxo livre e dieno e trieno conjugados em comparação com óleo de fritura repetidamente tratado com hibisco. Também há aumentos significativos no colesterol e triglicérides e comprometimento das funções hepáticas no "G3" em comparação com outros. Além disso, em relação aos grupos de hibiscos, há uma redução substancial no consumo de oxigênio no "G3". Tanto o hibisco como o hibisco irradiado chamam atenção por desempenhar papel vital e econômico contra os efeitos nocivos do uso frequente de óleo comestível para fritar em algumas funções biológicas, mas o hibisco irradiado foi mais eficaz.

How heated vegetable oil age? Effect of the container of heating on ageing.

This study compares the ageing process of heated oil with unheated oil and assesses the effect of container used in heating on ageing. Four types of oils were heated on glass, copper and iron. The samples were allowed to age for 1 year. Unheated oils generally produce peroxide faster (for unheated maximum increase in 6-month is 2907 % from 1.351 to 40.627 but for heated maximum increase is 6574 % from 1.91 to 127.476). But they develop secondary oxidation products slowly (for unheated maximum increase in 6-month is 884 % from 1.553 to 15.29 but for heated maximum increase is 191 % from 6.42 to 18.72). For most oil heating in copper produce more p-anisidine value during ageing. The acid value of only unheated oils decreases between 6 months to 1 year. For the 1st six-month rate of increase in saponification value in unheated oil is much higher. The DPPH inhibition activity also changes differently.

Effects of genotype, environment and their interaction on protein and amino acid contents in soybeans.

Soybean [Glycine max (L.) Merr.] is an important source of protein and oil. Genotype, environment and the interaction of genotype × environment influence the protein composition in soybean seeds. The main objectives of this study were to i) study the influence of genotype, environment and their interaction on soybean protein and amino acid contents; ii) evaluate the stability of soybean genotype across various environments, with a focus on soybeans grown in a northern latitude; and iii) identify the correlation between crude protein and critical amino acid value (CAAV). Twenty-three soybean genotypes were grown at four locations in Manitoba, Canada for two years (2018 and 2019). Soybean seeds were analyzed for protein and amino acids (nine essential amino acids and cysteine). The effects of genotype, environment and genotype × environment interaction on all traits were significant (P < 0.05). Genotype and environments explained the main part of variation for all traits. G13 and G15 cultivars performed better in favorable environments (bi > 1), and G22 cultivar showed greater resistance to environmental change. Protein and amino acids responded differently to various environments, but the optimal environments for greater soybean protein and amino acid remains to be established. The CAAV had a negative linear relationship with protein content in soybean (k = -0.17). This work expands our knowledge of the factors impacting the protein quality of soybeans grown in northern latitudes.

Spectroscopic studies on thermal degradation and quantitative prediction on acid value of edible oil during frying by Raman spectroscopy.

The health risks posed by harmful substances resulting from the thermal degradation of frying oils are of great concern. Characteristic peak intensity ratios (PIRs) screened from Raman spectra were used to characterize the thermal degradation. High correlation coefficients between PIRs and acid values (AVs) of 0.972 (linear fitting), 0.984 (logarithmic function fitting), and 0.954 (linear fitting) for fried soybean oil, canola oil, and palm oil, were obtained at the PIRs of I1267/I1749, I1267/I1659, and I1267/I1749, respectively. The highly correlated PIRs common to the three oils were determined by Pearson's correlation coefficient combined with heat maps. To accommodate both linear and nonlinear features, a global model for predicting AVs of multi-varieties frying oils was constructed using a least-squares support vector machine algorithm, and the results performed well with a root mean square error of prediction of 0.016 and a ratio of prediction to deviation of 11.351. The whole results demonstrate that Raman spectroscopy could characterize the thermal degradation and has excellent quantitative analysis ability for food control based on AV in frying oils, thus providing a new approach to quality control of frying oils.

Lipid oxidation in fragrant rapeseed oil: Impact of seed roasting on the generation of key volatile compounds.

This work sought to identify the influence of roasting on lipid oxidation-derived volatile compounds in fragrant rapeseed oils (FROs) via gas chromatography-mass spectrometry and gas chromatography-ion mobility spectrometry. Seven volatiles could be regard as aroma-active compounds by application of odor activity value (OAV ≥ 1) calculation, and caused fatty-like, nutty-like, and green-like notes. After 60 min of roasting, the OAVs of hexanal, octanal, (E,E)-2,4-heptadienal, and nonanal in FROs were greater than 3. The same compounds, including hexanal, (E,E)-2,4-heptadienal, nonanal, 1-octanol, and nonanoic acid were also detected in the model systems of lipid oxidation. Notably, the values of p-anisidine, conjugated dienes, and conjugated trienes increased significantly (p < 0.05). Furthermore, correlation analysis showed that hexanal, (E,E)-2,4-heptadienal, and nonanal have a significant positive correlation with the oxidative degree of FROs (R = 0.70-0.94, p < 0.05). Thus, the three above-mentioned aldehydes could serve as important markers for FRO quality during roasting.

Utilization of Diaphragma juglandis extract as a natural antioxidant for improving the oxidative stability of soybean oil during deep frying.

Lipid oxidation significantly shortens the life of frying oils, and this challenge can be addressed by using antioxidants. This work aimed to investigate the effect of Diaphragma juglandis extract (DJE) on the oxidative stability of soybean oil during deep frying. Tert-butylhydroquinone (TBHQ) and tea polyphenol (TP) were applied as positive controls. A total of 31 polyphenols were determined in DJE, and catechin, quercitrin, taxifolin, quercetin 3-ß-d-glucoside, epicatechin, gallic acid, and 3,4-dihydroxybenzoic acid were the main components. The antioxidants effectively delayed the degradation of triglycerides and inhibited the increase in the contents of p-anisidine, oxidized triglyceride monomers, triglyceride dimers, and triglyceride oligomers, with DJE exhibiting better performance. Moreover, DJE showed better inhibitory effect on the formation of (E)-2-alkenals, (E,E)-2,4-alkadienals, 4-oxo-alkanals, primary alcohols, and secondary alcohols detected by 1H nuclear magnetic resonance than TBHQ and TP. Therefore, DJE has great potential as an excellent antioxidant in large-scale industrial applications.

Application of NIR spectroscopy for rapid quantification of acid and peroxide in crude peanut oil coupled multivariate analysis.

Two key parameters (acidity and peroxide content) for evaluation of the oxidation level in crude peanut oil have been studied. The titrimetric analysis was carried out for reference data collection. Then, near-infrared spectroscopy in combination with chemometric algorithms such as partial least square (PLS); bootstrapping soft shrinkage-PLS (BOSS-PLS); uninformative variable elimination-PLS (UVE-PLS), and competitive-adaptive reweighted sampling-PLS (CARS-PLS) were attempted and assessed. The correlation coefficients of prediction (Rp), root mean square error of prediction (RMSEP) and residual predictive deviation (RPD) were used to individually evaluate the performance of the models. Optimum results were noticed with CARS-PLS, 0.9517 ≤ Rc ≤ 0.9670, 0.9503 ≤ Rp ≤ 0.9637, 0.0874 ≤ RMSEP ≤ 0.5650, and 3.14 ≤ RPD ≤ 3.64. Therefore, this affirmed that the near-infrared spectroscopy coupled with CARS-PLS could be used as a simple, fast, and non-invasive technique for quantifying acid value and peroxide value in crude peanut oil.

Quality Assessment of Deep-Frying Palm Oil by Impedimetric Sensing with a Simple and Economic Electrochemical Cell.

Quality control of deep-frying oil is a global public health concern. A simple and economic electrochemical chamber composed of two bare screen-printed carbon electrodes (working area: 78.54 × 102 cm2; distance: 0.0055 cm; cell constant: 0.70 × 10-2 cm-1) was constructed for precisely acquiring the impedimetric responses of a high-resistance palm oil sample (RSD < 7%, n = 3). Good correlations between the measured impedance data (charge transfer resistance and logarithmic output impedance (Log Z) obtained in the frequency region <0.1 Hz) and the regulatory quality indicators (total polar compounds and acid value) were achieved (R2 > 0.97), suggesting that the proposed impedimetric sensing method is useful for accurately assessing the deteriorated condition of repeated frying oil. Applications for rapid screening can also be realized because the measurement times of Log Z at any given perturbation frequency from 0.01-1 Hz were all less than 3 min.

Quantitative and qualitative assessment on the suitability of seed oil from water plant (Trichilia emetica) for soap making.

Despite widespread and its local available as a naturalized hedge and shade plant, the potential of Trichilia emetica was not utilized in soap making by the majority of local community in various parts of Dodoma, Tanzania. This study aimed to assess the quantity (yields) and quality (Acid Values (AVs), %Free Fatty Acids (%FFAs) and Saponification Values (SVs) of seed oil from water plant (T. emetica), suitable for soap making application. Solvent extraction method was used during oil extraction, where by 50gm of preheated and powdered seed materials were immersed in 250 ml of n-hexane in 1:5 (w/v) to dissolve the oil contained in the seed cake. The oil was collected by vaporizing solvent out through Rotary evaporation at 60 °C. Also standard titration methods were used to obtain SVs, AVs and %FFAs of the extracted oil. Results showed that T. emetica seeds contained higher quantity of oil (48.4%-50.2%) than many reported commercial plant seed oils. Also, the study found higher AV (7.4 mgKOH/g-7.8 mgKOH/g), %FFA (3.7% to 3.9%) and SVs (189.5 mgKOH/g - 191.4 mgKOH/g) than the maximum acceptable limits of 0.50 mg KOH/g, 0.020% and 175 mgKOH/g - 187 mgKOH/g prescribed by ASTM standards (2002). The obtained results showed that, T. emetica seeds yielded high oil quantity with low qualities due to higher levels of acidity. But high SVs guarantees the possibility of using T. emetica seed oil in soap making. However, the oil requires purification in order to bring levels of acidity to acceptable standards and guarantee its normal use in soap making.

Determining the Reuse of Frying Oil for Fried Sweet and Sour Pork according to Type of Oil and Frying Time.

Food Codex regulations have set freshness limits for oils used to fry food, such as potato and fish products, and fried food itself; however, no such freshness limits have been set for meat products, such as sweet and sour pork. The freshness standard suggest that acid values (AVs) and peroxide values (POVs) for frying oil should be less than 2.5 and 50, respectively, whereas AVs and POVs for common fried food should be less than 5.0 and 60, respectively. Therefore, in this study, we investigate the effect of the number of frying cycles on oxidation-promoted changes in the oils used to fry sweet and sour pork and fried food itself during repeated frying over 10 d by determining their AVs and POVs, which were found to be highly correlated. Soybean, canola, palm, and pork lard oils could be reused approximately 37, 32, 58, and 87 times, respectively, to fry sweet and sour pork based on oil freshness, and 78, 78, 81, and 286 times, respectively, based on the freshness of fried food. Our data may help establish food-quality regulations for oils used to fry animal-based foods.

Characterization of physico-chemical properties and antioxidant activity of oil from seed, leaf and stem of purslane (Portulaca oleracea L.).

Purslane (Portulaca oleracea L.) is a member of the family of portulacaceae and is a very good source of alpha-linoleic acid. Alpha-linoleic is an omega-3 fatty acid which plays an important role in human growth, development and in preventing diseases. Characterization of the physicochemical properties and antioxidant activity of oil from seeds, leaves and stems of purslane, and appraisal of its viability is the main purpose of this study. In this work, physicochemical properties of oil from seed, leaf and stem of purslane were characterized and the highest oil content was observed in seed (11.25 %) using solvent extraction method. The highest specific gravity was recorded for seed oil (1.10 w/w) followed by leaf oil (0.73 w/w) with non-significant difference. Moreover, oil extracted from purslane stem was found to be the least in oil content (2 %) and specific gravity (0.14 w/w); but the highest in acid value (13.32 w/v) and percentage free fatty acid. The peroxide value was found to be the highest for seed oil and the least for stem with significant difference. The highest ascorbic acid content was recorded for purslane seed oil (41.67 %) followed by leaf oil (32.29 %). Likewise, the highest 1, 1- diphenyl-2-picrylhydrazine activity was obtained for leaf oil (12.55 %) followed by seed oil (2.05 %). The plot for PC2 vs PC1 showed the oil content, specific gravity, peroxide value, ascorbic acid and 1, 1- diphenyl-2-picrylhydrazine having close PC1 and PC2 scores with vector angle < 90 0 showing correlated effects. Characterizing physical and chemical properties and antioxidant activity of oil from seeds, leaves and stems of purslane is crucial in providing necessary information for the utilization of the oil content.

Physicochemical parameter based estimation of discarding points for frying oil using data interpolation and principal component transformation.

Data interpolation and principal component transformation (PCT) were used to compute the discarding points of a frying oil by measuring the physicochemical parameters-acid value, carbonyl value, and total polar compounds. Herein, the discarding point refers to the time point (associated with the value of each physicochemical parameter) at which the frying oil should be discarded. First, a primary visual analysis was performed for the obtained data by using line charts. Second, a curve interpolation method was used to compute the discarding points for each parameter and thus determine the discarding points for the frying oil. At 190, 205, and 220°C, the frying oil reached the discarding points at 22.1, 17.7, and 13 hr, respectively. The discarding area was also visualized on the corresponding surfaces for the originally obtained data and the interpolated data to investigate the discarding points. Third, the PCT was conducted for the three parameters at each temperature; the discarding point estimation for the three parameters could be reduced to the estimation from the first principal component (FPC), thereby simplifying this process. At 190, 205, and 220°C, the frying oil reached the discarding points when the FPCs were 10.4524, 6.2881, and -1.7629 at the time points 22.1, 17.7, and 13 hr, respectively. Finally, a verification experiment revealed that the correlation between the results obtained by our interpolation method or PCT and the verified data was higher than 0.98, which demonstrates the effectiveness of our method.

Contactless and Simultaneous Measurement of Water and Acid Contaminations in Oil Using a Flexible Microstrip Sensor.

The assessment of the petroleum product quality often involves multiple indicators, among which water content and acid value are two major parameters. The complexity of an oil sample and the narrow space in pipeline transport make it difficult to monitor the oil quality in real-time. Considering the practical requirements, a new type of flexible microstrip sensor is proposed in this work. The shape and line width of the microstrip sensor are studied and optimized by theory and experiments. The proposed square spiral-based microstrip sensor has good water content detection resolution at high frequencies with less acid interference, and it can determine the acid value in the low-frequency band. The sensor surface is further passivated, protecting it from direct contact with the oil sample to enhance the electrochemical robustness, and still achieves good detection linearity and high sensitivity. After encapsulation on a flexible substrate, the proposed microstrip sensor realized the non-contact determination of the water content and acid value of oil at the same time, which is only a few millimeters in size and can conform to various tubing wall shapes. Due to the fact that the manufacture of the sensor is CMOS-compatible, we expect it to be readily applied to many other miniaturized chemical-sensing applications.

Antioxidant (Tocopherol and Canolol) Content in Rapeseed Oil Obtained from Roasted Yellow-Seeded Brassica napus.

In this study, the effect of temperature (140, 160, 180 °C) and roasting time (5, 10, 15 min) on the bioactive compound content (canolol, tocopherol and plastochromanol-8) of cold-pressed oil from yellow-seeded rapeseed lines of different colors was investigated. Roasting increased the peroxide value in the seed oils compared to the oils from the control samples. However, roasting did not affect the acid values of the oils, which were 1.15-1.47 and 1.30-1.40 mg KOH/g, for line PN1 03/1i/14 (yellow seeds) and line PN1 563/1i/14 (brown seeds), respectively. In this study, the seeds of line PN1 03/1i/14 were characterized by different changes in canolol content during roasting than the seeds of PN1 563/1i/14. There was a 90-fold increase in canolol for the line PN1 03/1i/14 (768.26 µg/g) and a 46-fold increase for the line PN1 563/1i/14 (576.43 µg/g). Changes in tocopherol and PC-8 contents were also observed. There was an increase in the contents of γ-T and PC-8 in the oils obtained from the seeds roasted at 180 °C for 10 and 15 min. γ-T content increased by 17-18% after 15 min of roasting, whereas the PC-8 content increased twofold.

Improvement of efficiency of oil extraction from wild apricot kernels by using enzymes.

An experiment was conducted to evaluate and standardize the protocol for enhancing recovery of oil and quality from cold pressed wild apricot kernels by using various enzymes. Wild apricot kernels were ground into powder in a grinder. Different lots of 3 kg powdered kernel were prepared and treated with different concentrations of enzyme solutions viz. Pectazyme (Pectinase), Mashzyme (Cellulase) and Pectazyme + Mashzyme. Kernel powder mixed with enzyme solutions were kept for 2 h at 50(±2) °C temperature for enzymatic treatment before its use for oil extraction through oil expeller. Results indicate that use of enzymes resulted in enhancement of oil recovery by 9.00-14.22 %. Maximum oil recovery was observed at 0.3-0.4 % enzyme concentration for both the enzymes individually, as well as in combination. All the three enzymatic treatments resulted in increasing oil yield. However, with 0.3 % (Pectazyme + Mashzyme) combination, maximum oil recovery of 47.33 % could be observed against were 33.11 % in control. The oil content left (wasted) in the cake and residue were reduced from 11.67 and 11.60 % to 7.31 and 2.72 % respectively, thus showing a high increase in efficiency of oil recovery from wild apricot kernels. Quality characteristics indicate that the oil quality was not adversely affected by enzymatic treatment. It was concluded treatment of powdered wild apricot kernels with 0.3 % (Pectazyme + Mashzyme) combination was highly effective in increasing oil recovery by 14.22 % without adversely affecting the quality and thus may be commercially used by the industry for reducing wastage of highly precious oil in the cake.

Effect of amurca on olive oil quality during storage.

Total phenolic compounds (TPC), antioxidant activity (AA), lipid peroxidation inhibition (percent) (LPOIP), free fatty acid and peroxide values were measured in olive oil samples over the period of 12 months in comparison with oil samples extracted from amurca (olive oil lees) and olive oil samples taken from the bottom of the canister (near amurca) after 12 months of storage. Olive oil samples taken over the period of 12 months possessed decreasing amounts of TPC, AA and LPOIP, which led to increased peroxide and free fatty acid values. In contrast, oil extracted from amurca and olive oil samples taken from the bottom of the container after 12 months of storage possessed significantly higher TPC, AA, LPOIP and consequently lower free fatty acid and peroxide values. These results show that the presence of naturally occurring amurca (sediment) in stored olive oil stabilizes olive oil quality during storage.